欢迎来到山东途畅路桥工程有限公司官网!

logo

  1. 专注强夯机租赁,液压冲击夯租赁、强夯工程施工碎石桩等
  2. 地基软基处理于一体的高质量基础工程施工公司

全国施工租赁热线

18264104888

强夯机检查需要检查哪些方面?

网址:http://www.sddhfjx.cn/   发布日期:2022-04-18 关注次数:0
一、发动机系统检查
1、 Engine system check
发动机是强夯的心脏一定要进行检查。
The engine is the heart of dynamic compaction and must be checked.
(一)燃油系统检查
(1) Fuel system inspection
1 检查燃油箱油量是否充足,颜色是否清澈
1 check whether the fuel tank has sufficient oil and whether the color is clear
2 燃油箱底部是否排水排污,观察污物情况
2. Check whether the bottom of the fuel tank is drained and polluted, and observe the dirt
3 油水分离器水杯是否有水
3 check whether there is water in the water cup of oil-water separator
4 燃油箱呼吸滤芯是否清洁
4 check whether the breathing filter element of fuel tank is clean
5所有的柴油管是否有老化开裂现象。
5 check whether all diesel pipes have aging and cracking.
(二) 润滑系统检查
(2) Lubrication system inspection
1 通过机油标尺观察机油液位,原则上液位在中位微微偏下,不能过高,过低。过高会造成发动机无力或无法启动,过低不利于润滑。
1. Observe the oil level through the oil dipstick. In principle, the liquid level is slightly lower than the middle level, not too high or too low. Too high will cause the engine to be weak or unable to start, and too low is not conducive to lubrication.
2 油底壳排放口排放少许机油,观察是否进水乳化或有其它杂物。
2 drain a little oil from the drain of oil pan and observe whether there is water emulsion or other sundries.
(三) 进排气系统检查
(3) Inspection of intake and exhaust system
1 检查进气内外空气滤芯是否清洁,如有污物低压空气吹洗,不能超过四次。严禁拍打和摔打。
1 check whether the air filter elements inside and outside the air inlet are clean. If there is dirt, purge with low-pressure air for no more than four times. Slapping and wrestling are strictly prohibited.
2 手动清理空气预滤器内灰尘和杂物。
2 manually clean the dust and sundries in the air pre filter.
3 有条件的情况下拆开中冷器的进气管,观察是否有油,如有需要更换涡轮增压器同时清洗中冷器。才能启动发动机。否则发动机易飞车。
3 if possible, disassemble the intake pipe of the intercooler and observe whether there is oil. If necessary, replace the turbocharger and clean the intercooler at the same time. To start the engine. Otherwise, the engine will run too fast.
(四) 冷却系统检查
(4) Cooling system inspection
1 检查主水箱液位是否正常,颜色是否纯正。
1 check whether the liquid level of the main water tank is normal and whether the color is pure.
2 观察水泵轴承箱排水孔是否通畅和漏水。
2 observe whether the drainage hole of the water pump bearing box is unobstructed and leaking.
3 起车时副水箱是否喷水和有气泡。
3. Check whether the auxiliary water tank sprays water and has bubbles when starting.
4 检查所有的水管是否老化及水箱是否有渗水现象。
4 check whether all water pipes are aging and whether the water tank has water seepage.
(五) 发动机附件检查
(5) Engine accessories inspection
1 发动机的地脚垫是否完好,是否老化。
1. Check whether the engine floor mat is intact and aging.
2 检查所有的皮带是否老化开裂,涨紧度正常。
2 check whether all belts are aged and cracked, and the tension is normal.
3 检查发电机,启动电机上是否有油污,防止大的电流引起火灾。
3 check whether there is oil stain on the generator and start the motor to prevent fire caused by large current.
以上就是为大家介绍的有关强夯机租赁的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.sddhfjx.cn
The above is a detailed introduction to the lease of cold dynamic compaction machine. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.sddhfjx.cn
  • 标签: